Eating High on the Hog
When it comes time to barbequing, there ain’t many finer eats than pulled pork, not in these parts of the country at least. Whether you grill it, smoke or cook the roast in the oven depends on you, your time and I guess the weather. Smoking is by far the best but I know a lot of you folks may not have a smoker so today, we’re gonna grill a pork roast that will come out just as good. I promise.
To me, the best roast for pulled pork is from the pork shoulder, by far. The terminology for pork shoulder can vary widely depending on the region. Pork shoulder is the top portion of the front leg of the hog, that’s a fact. Now, the Boston blade roast comes from the upper part of the shoulder and is also called the Boston Butt. This is located near the loin and hence contains the shoulder blade bone. The lower 'arm' portion of the shoulder is the arm picnic. According to the National Pork Board, “in pre-revolutionary New England and into the Revolutionary War, some pork cuts (not those highly valued, or "high on the hog," like loin and ham) were packed into casks or barrels (also known as "butts") for storage and shipment. The way the hog shoulder was cut in the Boston area became known in other regions as "Boston Butt." This name stuck and today, Boston butt is called that almost everywhere in the US ... except in Boston."
This is the way I enjoy cooking a Boston Butt, but any pork roast will do as long as there is a nice layer of fat on top and good marbling running through it. You need this to keep the meat moist, as the fat will cook out. The secret comes in three steps: the rub, the smoke and the wrapped cooking stage. You will also need a good meat thermometer. Go ahead, go out, buy a butt, and let’s get to cooking…
BBQ Pulled Pork
First up is purchasing a good butt. Choose one about the size of a football; say 8 to 10 pounds with a nice layer of fat (1/4 to 1/2 inch thick) covering the top. Trim the layer of fat to an even 1/4 inch. I like a bone-in but if you get a boneless, make sure to tie it up good. Some folks like to rub down the roast with all sorts of things like mustard, pepper jelly, you name it, and that's okay, to me sugar just causes the outer part to burn. I like to massage the roast with cooking oil and use a good spice rub, one without sugar, again, no cause to burn the roast.
Now for the rub, I’ve posted this before and like I’ve said it’s a versatile rub for pork but oh so good. Use your own if you think you’ve got one better.
BBQ Rub for Pork
4 tablespoons chipotle chili pepper
3 tablespoons salt
2 tablespoons dry mustard
2 tablespoons crushed oregano
2 tablespoons finely crushed dried rosemary leaves
2 tablespoons paprika
2 tablespoons garlic powder
1 1/2 tablespoons black pepper
1 tablespoon onion powder
1 tablespoon cayenne pepper
1/2 tablespoon dried thyme
Sprinkle the roast generously with the rub and coax it into any cavities. Wrap roast in plastic wrap and refrigerate for at least a couple of hours or overnight. Remove from the fridge for about 45 minutes before grilling.
Prepare your grill for indirect (off the heat cooking) on either gas or charcoal. Soak wood chips for an hour, I like hickory with maybe an apple blend the best and prepare a chip box or make a foil pack like I sometimes do. You can see how I make my foil pack here on my Cowboy Beef Brisket post. Get the grill going and the temperature to 250 degrees F. You need to keep it between 225 and 250 during the cooking process.
Place chip box or foil pack on the fire side and place the roast on the cool side with fat side up. Close the lid and wait, this is all you can do for now.
|July 4th Grilling|
At this point you can slice it, chopped it or dice it – but why come all this way without shredding it folks. That’s why we’re here, right? It should be tender enough to pull with your finger if you want large chunks. Now, if you want the shredded version, take two forks and working against each other, start at one end of the roast and pull the meat apart.
Serve with your favorite barbeque sauce, reheat the mopping sauce to moisten the meat or sprinkle it with a little black pepper, cider vinegar and apple juice for a real southern taste.